进口不锈钢气动隔膜泵原理特点及品牌（图）

发布日期：2021-01-19 14:15:26 来源：互联网

进口不锈钢气动隔膜泵原理特点

进口不锈钢气动隔膜泵是德国托马斯(Thomas)开发的第三代气动隔膜泵，具有使用寿命长，不会停顿等优点，它既能抽送流动的液体，又能输送一些不易流动的介质，具有自吸泵、潜水泵、屏蔽泵、泥浆泵和杂质泵等输送机械的许多优点。

产品特点

1、不需灌引水。吸程高达5m，扬程达70m，出口压力≥6bar。

2、流动宽敞，通过性能好，允许通过大颗粒直径达10mm。抽送泥浆、杂质时，对泵磨损甚微；

3、扬程、流量可通过气阀开度实现无级调节(气压调节在1-7 bar之间)；

4、该泵无旋转部件，没有轴封，隔膜等抽送的介质与泵的运动部件、工作介质完全隔开，所输送的介质不会向外泄漏。所以抽送有毒、易挥发或腐蚀性介质时，不会造成环境污染和危害人身安全；

5、不必用电，在易燃、易爆场所使用安全可靠；

6、可以浸没在介质中工作；

7、使用方便、工作可靠、开停只需简单地打开和关闭气体阀门。即使由于意外情况而长时间无介质运行或突然停机泵也不会因此而损坏，一旦超负荷，泵会自动地停机，具有自我保护性能，当负荷恢复正常后，又能自动启动运行；

8、结构简单、易损件少，该泵结构简单，安装，维修方便，泵输送的介质不会接触到配气阀，联杆等运动部件，不象其他类型的泵因转子、活塞、齿轮、叶片等部件的磨损而使性能逐步下降；

9、可输送较粘的液体(粘度在1万厘泊以下)；

10、本泵无须用油润滑，即使空转，对泵也无任何影响，这是该泵大特点。

产品用途

泵吸花生酱、泡菜、土豆泥、红肠、巧克力、啤酒花、糖浆等

油漆、颜料、胶水、粘合剂等

各种瓦、瓷、砖器及陶瓷釉浆

各种磨料、腐蚀剂、清洗油垢

各种剧毒、易燃、易挥发液体

各种污水、水泥灌浆及灰浆

各种强酸、强碱、强腐蚀液体

各种粘稠浆、乳化液、各种软膏化装品

各种固液分离设备的前级送压装置

Stainless steel pneumatic diaphragm pump is developed by the German Thomas the third generation of pneumatic diaphragm pump, with a long life, will not pause, etc., it can pump the flow of liquid, but also transport some easy flow of media, with Self-priming pumps, submersible pumps, shield pumps, mud pumps and impurity pumps.

Features

1, without irrigation water. Suction up to 5m, head up to 70m, the outlet pressure ≥ 6bar.

2, the flow of spacious, through the performance is good, allowing the maximum particle diameter of up to 10mm. Pumping mud, impurities, the pump wear is minimal;

3, head, the flow through the valve opening to achieve stepless adjustment (air pressure adjustment between 1-7 bar);

4, the pump without rotating parts, no shaft seal, diaphragm and other pumping media and pump moving parts, the working medium completely separated, the transmission of the media will not leak out. So the pumping of toxic, volatile or corrosive media, will not cause environmental pollution and harm to personal safety;

5, do not have electricity, flammable, explosive use of safe and reliable place;

6, can be immersed in the media work;

7, easy to use, reliable, open only need to simply open and close the gas valve. Even if the accident due to a long time without the media to run or suddenly stop the pump will not be damaged, once overload, the pump will automatically shut down, with self-protection performance, when the load back to normal, but also automatically start running;

8, the structure is simple, less wearing parts, the pump structure is simple, easy installation, easy maintenance, pump delivery media will not come into contact with the valve, connecting rod and other moving parts, unlike other types of pumps due to the rotor, , Leaves and other components of the wear and tear of the performance gradually decreased;

9, can transport more viscous liquid (viscosity in less than 10,000 centipoise);

10, the pump without oil lubrication, even if the idle, the pump has no effect, this is the biggest feature of the pump.

Product Usage

Pumped peanut butter, pickles, mashed potatoes, sausage, chocolate, hops, syrup and so on

Paint, paint, glue, adhesives and so on

All kinds of tile, porcelain, brick and ceramic glaze pulp

All kinds of abrasive, corrosion agent, cleaning grease

A variety of highly toxic, flammable, volatile liquid

All kinds of sewage, cement grouting and mortar

All kinds of strong acid, strong alkali, strong corrosive liquid

All kinds of viscous pulp, emulsion, all kinds of ointment cosmetics

A variety of solid-liquid separation equipment of the former pressure device

进口不锈钢气动隔膜泵品牌

上一篇：进口铸铁气动隔膜泵原理特点及品牌（图）下一篇：进口工程塑料隔膜泵原理特点及品牌（图）

相关产品

• 进口铜球阀

• 进口浮球阀

新闻资讯

• 进口气动薄膜调节阀（图）2021-01-17 17:53:51
• 进口不锈钢电动调节阀（图）2021-01-17 17:53:51
• 进口氧气套筒调节阀（图）2021-01-17 17:53:49
• 进口泄氮阀（图）2021-01-17 17:53:48
• 进口气动精小型调节阀（图）2021-01-17 17:53:47
• 进口气动低温调节阀（图）2021-01-17 17:53:45
• 进口气动衬氟调节阀（图）2021-01-17 17:53:43
• 进口气动三通调节阀（图）2021-01-17 17:53:42
• 进口气动隔膜调节阀（图）2021-01-17 17:53:42